Security

Another rewrite for 737 Max software as cosmic bit-flipping tests glitch out systems – report

Third time's a charm?


Further details have emerged on the 737 Max flight control software bug discovered at the end of June, with reports suggesting that belated tests by a US regulator found the hitherto unknown bug.

The Seattle Times, Boeing's hometown newspaper for many years, explains in detail how timid Federal Aviation Authority regulators eventually woke up and began doing their jobs in full after the two Boeing 737 Max crashes earlier this year.

During tests intended to check for malfunctions of the 737 Max's redesigned flight control software, the pilots still managed to lose control of a simulated aircraft during ground exercises. The test which caused them to lose control involved flipping bits in the memory of one of the Boeing's two flight control computers.

Flipping bits, the article explains, is intended to simulate a rare but not impossible situation where cosmic rays striking the memory of electronic components in flight can reset bits from 0 to 1. With 737s routinely flying up to 37,000ft, the possibility of this happening increases with altitude.

Testing focused on flipping five bits, said to control some of the most crucial parameters: positioning of flight controls and activation state of flight control systems, such as the infamous MCAS anti-stall system.

Astonishingly, until the 737 Max crashes, the aircraft was flying with no redundancy at all for the flight control computers. If the active one failed or suffered inversion of critical bits in memory, there was no standby unit ready to cut in and continue. The Seattle Times reported that this has now been redesigned so the two onboard computers run in an active:standby configuration. Previously the units merely swapped over in between flights.

In addition, the computers will receive input from both angle-of-attack sensors rather than just the one. A faulty AoA sensor is thought to have been a contributory factor to the 737 Max crashes, which together cost more than 300 lives.

Boeing is now working on yet another set of fixes in the hope that the 737 Max (or 737-8200, as some think the troubled aircraft may be rebranded) can regain certification from American authorities by October. Whether the rest of the world will trust the US FAA is unknown, however; China led the worldwide regulatory push to ground the unsafe aircraft, and despite Boeing's well-reported close relationship with the American regulator, the odds of all the world's civil aviation authorities taking it at its word is now lower than it was before the crashes. The US FAA was, predictably, the last major authority to take action and ground the dangerous aircraft.

The Seattle Times reported: "According to a third person familiar with the details, Boeing expects to have this new software architecture ready for testing toward the end of September. Meanwhile, it will continue certification activities in parallel so that it can stick to its announced schedule and hope for clearance from the FAA and other regulators in October."

As we reported previously, the flaw was thought to have been caused by a revised version of the 737 Max's firmware, triggering some unknown condition that caused a microprocessor in the active flight control computer to lock up. ®

Send us news
195 Comments

Boeing top brass stand down amid safety turbulence

They were all planning on leaving anyway, company claims

Justice Dept reportedly starts criminal probe into Boeing door bolt incident

Plus: Pilots on Lion Air’s Batik fall asleep and miss Jakarta

Boeing paper trail goes cold over door plug blowout

Safety watchdog bemoans lack of cooperation with probe

FAA gives Boeing 90 days to fix serious safety shortcomings found in report

Expert panel finds 'a lack of awareness of safety-related metrics at all levels,' and more, at plane maker

Boeing-backed air taxi upstart Wisk plans to fly you across town at UberX prices by 2030

Absence of an on-board pilot will lower costs and raise blood pressure, starting soon in Texas

Aircraft rivet hole issues cause delays to Boeing 737 Max deliveries

Supplier to beleagered US aerospace giant spots problem, which would not be an 'immediate flight safety issue'

Boeing goes boing: 757 loses a wheel while taxiing down the runway

That old kit isn't our fault Boeing tells us

United Airlines’ patience with Boeing is maxed out after repeated safety issues

Plans for life without the 737 Max 10 after CEO rated door plug blowout 'the straw that broke the camel's back'

Travel app Kayak offers Boeing 737 Max 9 filter after that door plug drama

Handy feature as FAA expands inspections to 737-900ER aircraft

Perfect timing... US Navy throws Boeing $103M to update its sub recon jets

Just as Secretary of State's 737 goes on the Blink(en) at Davos

Technology truly is the gift that keeps on giving ... SNAFUs to highlight

Until we can hook schadenfreude directly into our veins, this will have to do

Nearly 200 Boeing 737 MAX 9 airplanes grounded after door plug flies off mid-flight

NTSB chair pushes for 25 hours of cockpit voice and flight data recordings